INSTALLATION INSTRUCTIONS FOR PART 95-5818
APPLICATIONS
FORD
F-150 2004 Heritage / F-150 1997-2003
Expedition 1997-2002
F650 2005-2008
LINCOLN
Navigator 1997-2002/Blackwood 2001-2003
95-5818
KIT FEATURES
• Double DIN Head Unit Provision
• Stacked ISO Mounts Units Provision
NOTE: Major sub dash modifications
are necessary to use this dash kit. You
will need to trim the sub dash to gain
suitable depth and height.
KIT COMPONENTS
•
A) & B) (2) Double Din Trim Plates • C) Double Din Brackets
WIRING AND ANTENNA CONNECTIONS
(Sold Separately)
Wiring Harness:
C
B
A
Antenna Adapter:
• Not required
TOOLS REQUIRED:
Dremel or Suitable Cutting Tool
• Panel Removal Tool • Socket Wrench
•
Small Flat Blade Screwdriver
Metra 86-5618 Removal Keys
•
1-800-221-0932
© COPYRIGHT 2009-10 METRA ELECTRONICS CORPORATION
95-5818 DASH DISASSEMBLY
FORD F-150 2004 HERITAGE/F-150 1997-2003
EXPEDITION 1997-2002/
F650 2005-2008/
LINCOLN NAVIGATOR 1997-2002/BLACKWOOD 2001-2003
A
Disconnect the negative battery ter-
minal to prevent an accidental short
circuit.
1
2
3
Unclip and remove the panel sur-
rounding the radio. (Figure A)
Using the Metra 86-5618 removal
keys, slide the radio out of the radio
cavity. Unplug and remove the radio.
(Figure B)
B
4
5
Remove the (4) 7 MM screws at the
sides of the factory climate control
and remove the factory climate con-
trol. (Figure C)
Cut and remove obstructions in dash
cavity. (Be careful not to cut into har-
nesses or electronic components)
(Figure D)
Continue to kit assembly.
D
C
CUT OUT
TOP
CUT BAR
CUT BAR
1
95-5818 KIT/FINAL ASSEMBLY
DOUBLE DIN/STACKED ISO MOUNT
UNIT(S) PROVISION
*Note: Refer also to the instructions included with the aftermarket radio.
NOTE: Major sub dash modifications are necessary to use this dash kit. You will
need to trim the sub dash to gain suitable depth and height.
A
Attach the double DIN brackets to
the double DIN or stacked ISO Mount
unit(s) using the screws supplied
with the unit(s). (Figure A)
1
B
2
Locate the factory wiring harness in
the dash. Metra recommends using
the proper mating adapter and mak-
ing the connections as shown.
A
B
(Isolate and individually tape off the
ends of any unused wires to prevent
electrical short circuit). (Figure B)
C
D
3
Re-connect the negative battery ter-
minal and test the unit for proper
operation.
(A) Strip wire ends back 1/2"
B) Twist ends together
C) Solder
Continued on page 3.
D) Tape
2
95-5818 KIT/FINAL ASSEMBLY
FINAL ASSEMBLY
NOTE: Major sub dash modifications are necessary to use this dash kit. You will
need to trim the sub dash to gain suitable depth and height.
Continued from page 2.
C
4
Slide the double DIN radio or stacked
ISO Mount unit assembly into the mod-
ified sub dash until it clicks into place.
5
6
Attach the appropriate double DIN trim
plate using the top 2 screw positions
of the climate control. (Figure C)
Reassemble the rest of the dash in
reverse order of disassembly.
FINAL WIRING CONNECTIONS
Make wiring connections using the EIA color code chart shown below and the instructions
included with the head unit. Metra recommends making connections shown below; Strip, Splice,
Solder, Tape. Isolate and individually tape off ends of any unused wires to prevent electrical short
circuit.
METRA / EIA WIRING CODE
12V Ignition / Acc. . . . . . . . . . Red
Right Front (+) . . . . . . . . . . . . Gray
12V Batt / Memory. . . . . . . . . Yellow
Ground. . . . . . . . . . . . . . . . . . Black*
Power Antenna. . . . . . . . . . . . Blue
Right Front (-). . . . . . . . . . . . . Gray/ Black
Left Front (+) . . . . . . . . . . . . . White
Left Front (-). . . . . . . . . . . . . . White / Black
Right Rear (+) . . . . . . . . . . . . Violet
Amp Turn-On . . . . . . . . . . . . . Blue / White
Amp Ground. . . . . . . . . . . . . . Black / White
Illumination . . . . . . . . . . . . . . Orange
Dimmer . . . . . . . . . . . . . . . . . Orange / White
Right Rear (-) . . . . . . . . . . . . . Violet / Black
Left Rear (+) . . . . . . . . . . . . . Green
Left Rear (-) . . . . . . . . . . . . . . Green / Black
*NOTE: When a Black wire is not present, ground radio to vehicle chassis. All colors may not be
present on all leads due to manufacturer’s specifications.
Enjoy your newly installed radio!
3
95-5818
NOTES
4
95-5818
NOTES
5
95-5818 INSTRUCTIONS
1-800-221-0932
REV. 06/08/10 © COPYRIGHT 2009-10 METRA ELECTRONICS CORPORATION INST95-5818
|